Products List

Main conrainer

side water depth for sludge thickener tank

PRIMARY CLARIFIER Sewage Treatment Water

Side water depth (2) Overhead space Primary sludge concentration (for calculation) Primary clarifier were sludge floating happened FS PRIM 002 Page 23 of 26 Figure 27 Scum trough Figure 28 Settling tank with raw water entry and peripheral extraction of clarified water

more+

History Carmel Area Wastewater District

The Sludge Thickener is located just north of the Aeration Unit, with the pressurization system, sludge and scum pumping, and polyelectrolyte feed equipment located on a concrete slab on grade adjacent to the Thickener Tank

more+

Module 16 : Primary Sedimentation Tank Lecture 21

2017 8 4 · height of the tank should be ideally equal to side water depth of the settling tank for proper results 3 Page rates are used when waste activated sludge is also settled in the PST along with primary Design the primary sedimentation tank to treat wastewater with average flow rate of 10 MLD and peak flow of 22 5 MLD

more+

Spec: Sludge Thickener Rexon Associates com

2017 11 2 · *2 2 3 Thickener shall have a top mounted fully suspended rake, to move the settled sludge to a center discharge port located in the tank bottom The rake mechanism shall produce * inch pounds of torque and be driven by a 440 VAC, 3 phase TEFC motor of a maximum * HP

more+

FSM H06 CS5 IHE Delft Institute for Water Education

2014 6 24 · opposite side, while settled solids are retained at the bottom of the tank, and scum fl oats on the surface Allowing room in the tank for sludge storage as it settles and accumulates is an important consideration in the design of tanks, because as sludge accumulates, it effectively reduces the depth of the tank available for settling This

more+

9VAC25 790 600 Sludge Thickening Xinhaiia Law

9VAC25 790 600 Sludge Thickening The side water depth of conventional gravity thickeners shall be a minimum of 10 feet Circular thickeners shall have a minimum bottom slope of 1 1/2 inches per radial foot 2 A gravity sludge thickener shall be so designed as to provide for sludge storage, if sufficient storage is unavailable within

more+

OVIVO® Thickener Worldwide Experts in Water

Tank configuration: accommodate existing and new tank, steep to flat tank bottom, shallow or deep side water depth The Ovivo® thickener mechanism uses the fundamental principal of gravity separation of solids from liquid to produce a clarified overflow water and sludge

more+

equation of thickener tank design by retenaion time

The sludge thickener reduces the water content in the Tank Equalization makes the waste water homogenous Retention time depends upon the capacity of treatment Determine the diameter of each tank and the nominal side water depth for design criteria of an overflow rate of 700 gpd/ft 2 and detention time of 3 hours at

more+

OVIVO ® Thickener

Tank configuration: accommodate existing and new tank, steep to flat tank bottom, shallow or deep side water depth The Ovivo® thickener mechanism uses the fundamental principal of gravity separation of solids from liquid to produce a clarified overflow water and sludge

more+

MODULE 9 Iowa State University

2001 4 11 · Most continuous flow thickeners are designed with a side water depth of approximately 3 5 m to provide an adequate clear water zone, sludge blanket depth, and space for temporary storage of consolidated waste sludge

more+

Solving a Water Plant Sludge Problem

2008 12 12 · Gravity Thickener Tanks: Each tank is 35 feet in diameter with a 22 3 vertical side water depth and a 10 10 conical bottom Each tank can store 199,000 gallons Two 6 inch perforated pipes ring the diameter of the tanks above the conical bottom at two different levels to remove the supernatant after the sludge has settled

more+

PRIMARY CLARIFIER Sewage Treatment Water

Side water depth (2) Overhead space Primary sludge concentration (for calculation) Primary clarifier were sludge floating happened FS PRIM 002 Page 23 of 26 Figure 27 Scum trough Figure 28 Settling tank with raw water entry and peripheral extraction of clarified water

more+

Circular Thickener Clarifiers Monroe Environmental

Circular Thickeners provide a crucial treatment step between upstream process screens, clarifiers, and separators and downstream dewatering and sludge conditioning processes A well designed thickener provides storage and equalization, reduces the volume of sludge

more+

Chapter 5 Solids Thickening Dewatering Jan 2005

Chapter 5 Solids Thickening and Dewatering Gravity thickeners typically consist of a circular tank with a side water depth of 10 to 13 feet Gravity thickener tank diameters range significantly Floor slopes of 2:12 to a 3:12 Solids and air particles float and form a sludge blanket on the DAF tank

more+

Improve Clarifier and Thickener Design and Operation

2016 3 24 · In this case, the sludge blanket is not allowed to develop, and excess water is pumped out of the thickener underflow Figure 9 shows an underflow of only 150 kg/m 3 of TSS (This is the same unit as just calculated, but run at a different underflow concentration )

more+

Sludge Thickening Sewage Treatment Reverse

Sludge is usually pumped continuously from the settling tank to the thickener which has a low overflow rate so that the excess water overflows and the sludge solids concentrate in the bottom A blanket of sludge is maintained by controlled removal which may be continuous at a low rate

more+

TECHNICAL MEMORANDUM CITY OF PALATKA, FLORIDA

Gravity Sludge Thickener Office/Laboratory Building each 139 feet in length, 28 feet in width, and side water depth of 12 feet Gravity Sludge Thickener Primary/Secondary sludge concentration is accomplished by conveyance to the Gravity Sludge withdrawn from the secondary digester and flows by gravity to the sludge holding tank

more+

Cost estimation and economical evaluation

The conventional (plug flow) activated sludge process uses an aeration tank, a settling tank (clarifier), and a sludge return line to treat wastewater Wastewater and return sludge from the secondary clarifier enter the head of the aeration tank to undergo a specific period of aeration

more+

3 8 Design example of a treatment plant Treatment

This means that the settling thickening tank has a total depth This slide shows the top view of the two settling thickening tanks With sludge flowing from the right to the left side waste water and faecal sludge treatment plant in Kampala

more+

Sludge Floc Behavior in an Elongated Rectangular Settling

vated sludge process, acting as a clarifier, a sludge thickener, and a sludge storage tank In the secondary settling tanks, three dif ferent types of settling phenomena occur: discrete, flocculent, and Side water depth m 4 0 Number of clarifier 12 Surface area

more+

Anaerobic Digestion of Wastewater Sludge dartmouth edu

2018 10 8 · receiving water (stream, lake or sea) sludge in need of further treatment The tank is capped to prevent oxygen from coming in, to prevent odors from escaping, and to capture the methane produced An example of gravity belt thickener and its product

more+

OVIVO ® Thickener

Tank configuration: accommodate existing and new tank, steep to flat tank bottom, shallow or deep side water depth The Ovivo® thickener mechanism uses the fundamental principal of gravity separation of solids from liquid to produce a clarified overflow water and sludge

more+

Thickener Tanks GAST

2018 10 13 · Thickener tanks are used to thicken liquid sludge from municipal and industrial waste water treatment plants By slow stirring of the sludge water, sludge is separated and sinks down to the bottom of the tank The water can be removed continuously or discontinuously from the tank and subsequently discharged into additional treatment stages The operational mode is chosen according to the

more+

Process Design Manual Sludge Treatment And Disposal

EPA 625/1 74 006 PROCESS DESIGN MANUAL FOR SLUDGE TREATMENT AND DISPOSAL U S ENVIRONMENTAL PROTECTION AGENCY Technology Transfer October 1974 Most continuous thickeners today are circular and designed with a side water depth of approximately 10 feet The most common ratio used for design of an excess activated sludge thickener is 0 02

more+

(PDF) Effect of Sludge Holding Tank on Nutrient

2018 1 8 · The objective of this study was to assess the potential of hydrolysis/fermentation of activated sludge (AS) in sludge holding tank (SHT) to increase the biological nutrient removal (BNR) efficiency

more+

Circular Clarifiers Thickeners Monroe Environmental

Circular Clarifiers and Thickeners New, rebuild, retrofit designs for nearly all clarifier and thickener applications the effluent is discharged along the outer wall of the clarifier tank Clarifiers with peripheral inlets will be designed with a center bottom liquid outlet Importance of Side Water Depth in Planning and Evaluating

more+

PRACTICAL DESIGN CRITERIA Aquanova

2013 9 2 · A131 recommends minimum side water depth 2,5 m and minimum average water depth 3 m Geometry of Rectangular Clarifiers Various guidelines recommend certain ratio of the length to the width, typically minimum ratio 5:1

more+

LIQUID / SOLIDS SEPARATION IN WASTEWATER

2011 11 2 · sludge (ras) waste water primary sludge sludge digester or holding tank 1 eff liquid phase filtrate, centrate, pressate sludge cake primary clarifier secondary rotary screen thickener incoming sludge polymer thickened sludge centrifuge line diagram motor liquid sludge in centrate sludge

more+

Deepwater, NJ Preload

one 300,000 Gallon sludge thickener tank with 60 inside diameter and 15 side water depth All nine of these wire wound prestressed concrete Preload tanks have been in

more+

Spec: Sludge Thickener Rexon Associates com

2017 11 2 · *2 2 3 Thickener shall have a top mounted fully suspended rake, to move the settled sludge to a center discharge port located in the tank bottom The rake mechanism shall produce * inch pounds of torque and be driven by a 440 VAC, 3 phase TEFC motor of a maximum * HP

more+

Importance of Side Water Depth in Planning and

Side water depth/sidewall depth is the depth of the water at the wall of the basin The application of the clarifier/settling tank has a lot to do with the selection of the side water depth For a grit collector where the material acts according to Stokes Law, the side water depth can be fairly shallow

more+

Chapter 5 Sludge treatment site iugaza edu ps

2011 9 10 · Chapter 5 Sludge treatment removing as much as possible of the water content of sludge, leading to the increase of the solids content of sludge Thickening is achieved by the following three methods: So, the thickener side wall depth (H) is calculated as :

more+